Hey has anyone here actually been turboed on stock internals for any length of time?? since hahns stage one is now 2300 and stars kit is only 1900, it seems even more appealing. if i get the stage one, get a starion intercooler and boost controller, what will i need fuel wise to run 8-9 pounds (ive heard that the star kit doesnt always provide enough fuel for these levels) and is this safe??? i dont plan on building the bottom end any time soon. One last question - and egt gauge uses a probe that needs to be installed in the manifold, alla drilling into it, correct, is this something that should be done before i install the manifold on the car, or can i do after??
sorry for the lengh and all the stupid questions. any help would be appreciated.
thanks

>Hey has anyone here actually been turboed on stock internals
>for any length of time?? since hahns stage one is now 2300
>and stars kit is only 1900, it seems even more appealing. if
>i get the stage one, get a starion intercooler and boost
>controller, what will i need fuel wise to run 8-9 pounds
>(ive heard that the star kit doesnt always provide enough
>fuel for these levels) and is this safe??? i dont plan on
>building the bottom end any time soon.

I've had my star kit on for about 7 months. i started at 7 psi and went to 9. And now i'm rebuilding my engine due to bad compression. If you want to run bost on stock internals for a long time i'd stay at 7psi, or even 5. Just to be safe.
I've had no problems with the fuel of the star, but some ppl have added the hrc inline fuel pump to the star set up, so they were runningto hi flow pumps.

>One last question -
>and egt gauge uses a probe that needs to be installed in the
>manifold, alla drilling into it, correct, is this something
>that should be done before i install the manifold on the
>car, or can i do after??
> sorry for the lengh and all the stupid questions. any help
>would be appreciated.
>thanks

You can have the egt gauge installed anytime even if you've got the manifold on, just take it to a muffler shop, they'll probably charge like $20 or so to mount it for ya.

thanks for the help... how many miles are on your car??

I ran 9 psi on my STAR stage 2 for 8 months (modified fuel system) and blew due to a tuning mistake. Other that, never had a problem.

______________________________
If a sentence found online has 35% misspellings or greater and includes at least two racially charged expletives, chances are it is a YouTube comment.

'95 Eclipse TurboGS (garage deco)
'95 TSi AWD (restoring a survivor)
'97 Talon ESi-T (poor impulse control)
'99 Eclipse RS-T (daily beater)
'13 Evo X (mostly stock)
'17 Sienna (Middle Aged Dad Mobile)



Factory Service Manuals: http://nawdu.de/files/

I have about 35,000 miles right now.

I have 86,000 miles on my car and it has been turboed since the begining of June. I have put about 12,000 miles on it since then and I havent had any major problems other than normal turbo maintance stuff like leaking oil due to loose oil lines and downpipe bolts falling out. I was running stage 1 for about a month but the rest of the time I have been running 5-6 psi on a stage 2.

Dave
05 Ford F150 SuperCrew FX4

i've been runin around for about 2weeks...first 3 then 10 then 5 then 8 psi respectively, lol...took a few tries to hook up the profecB correctly do to a lack of instructions.

-bryan
'98 rst

thought you had a custom system mitseclps? Anyway I've got bout 20k on my car star turboe'd stage 1. Getting boosting controller soon though . Car still runs great. Haha yeah I get bolts popin off of my manifold and downpipe, use thread lock worked for me ^_^! I heard lotta people were running lean and blowing up engines but mine seems fine. Got an Airtex Inline pump with my kit so it'm running hella RICH right now, plus that darn starion intercooler took one psi from me so I gotta get it back with a boost controller. Bwahhaah 20 dolla boost controller off of ebay!

Just make sure you turbocharge and tune your car properly, get an EGT, AF guage, and obviously you'll have a boost gauge. Properly tune and monitor your car and it'll have a happy life turbocharged.

http://www.hadesomega.info -car specz and movies 95 Eclipse RS | 76' 280Z | 89' MR2 | 99 Neon | 91 Zephyr
Who sez FF can't drift?

thanks for all your help guys... looks like ill be ordering my kit next week.

it is a custom kit, but i have the same turbo, so i decided to respond.

-bryan
'98 rst

i like ur handle


96RS ~ full 99GS Special Edit. body conversion, aem cai, greddy header, greddy sp exhaust, afx pulley, B&M sS, magecores & NGKs, S-AFC, A/F and Volt guages, Sparco Torino Seat, illuminas, prokits, ingalls camber, gunmetal GS rims, ST Sways, STBs, lower rear tie bar, Sony Xplode head, Xplode 10 disk, Boston Components, 2 Kenwood amps, 12" MTX sub, a shit load more.


97GSX ~ 18psi~ Ported/Clipped 10 degrees Frank 2 w/47trim, Ported Exh. housing, Tial 40mm External Wastegate with discharge tube, Ported O2 housing, 3" downpipe, 3" Straight Pipe, Apex N1, fake cat, K&N FIPK, Greddy IC Piping, Type S bov, S-AFC, Profec B, Greddy TT, Slimline Fan, RRE Catch Can, Greddy Big FMIC, ND 660s, Walboro 190lph, ACT 2600 w/street disk, clutch SS line, lighten flywheel, removed cruise control line, Greddy EGT, Coolant, Boost Gauges, motor mount inserts, Magnecor & plugs, greddy oil cap, greddy radiator cap, and free mods. To all the haters _|_ tia

The Original 2GNT []D[][]Y[][]D


96 RS


97 GSX

thanks bro

Turbocharged for 5,000 miles got a boost controller about a month after I got my kit and ran around 3,000 miles with 10 psi(major fuel problems) back down to 8psi and have no problems now. My car has 63,000 miles on it.... have had the turbo on for over 6 months now...

haha I like that screen name

http://www.hadesomega.info -car specz and movies 95 Eclipse RS | 76' 280Z | 89' MR2 | 99 Neon | 91 Zephyr
Who sez FF can't drift?

Been runnin' Star Stage 2 for over a year with no problems... I have about 20K miles of daily 7psi driving... I have ZERO regrets for ordering a Star vs. HRC. Both are good, but I know HRC is there for support if you ever have a problem or need an upgrade... Worth the extra $$$ IMO...

Laterz.

'99 Eclipse GS Sports Edition
Star Stage 2
Greddy EVO Exhuast
AEM Big Brakes
Greddy Type S BOV
Pioneer DEH-P7200
Bazooka EL1500 running 2 MTX 10" Subs
Fosgate Separates throughout

I had stage II on stock internals for a good year and a half.

RAIZIN what happened after a year and a half? Did it blow or did you decide to upgrade?

hey RAIZIN can you respond to my emails???

Toney
'97 RS 5 Speed (totaled)
15.4606@88.42 Mph
96 Toyota Celica GT
88 Toyota Supra NA-T (w/ sports package)
Got Boost?? Hell yeah I-6 turbo powah baby!

haha.. I'm on my fourth engine.. all the G'z on this board know all about my 420A history.

Toney.. I have responded.. did you send anymore?

ok Rick, I sent you another email and I sent it to your rpaguio@chsd.org email address. I hope you get it

Toney
'97 RS 5 Speed (totaled)
15.4606@88.42 Mph
96 Toyota Celica GT
88 Toyota Supra NA-T (w/ sports package)
Got Boost?? Hell yeah I-6 turbo powah baby!