#105005, "Sunroof leak HELP" Nov-03-10 12:52 AM by intimidator2003
My sunroof is leaking and I thought that the drain tube was probably clogged but when I looked my sunroof has no drain tubes. How do I go about fixing thIs leak?
#105009, "RE: Sunroof leak HELP" In response to Reply # 2
You wont see "drain tubes" but you should see drain holes. Those holes lead to small tubes that run down the side of the car. You could try using the "stream" setting on your backyard hose to try and force anything that is clogged in there out, but be careful. If you use too much pressure, you run the risk of blowing off the tubes.
Also, continuing to assume it is NOT an aftermarket sunroof, make sure it is properly adjusted via the 6 hexbolts. The sunroof should be 1mm below the roofline in the front and 1mm above the roofline in the back. Make sure to use loctite on the bolts when you retighten them or you will inevitably be doing this adjustment again sometime soon.
Finally, how does the sealing element that runs the perimeter of the sunroof look?
1999 Eclipse GS Built motor Hahn 16G Turbo w/ FMIC Hahn Stage 5 Portfueler (270's & 500's) Zeitronix Zt-2 wideband w/ 3.5bar MAP 3" SS Turbo Back CM Stage 4 Clutch and Fidanza Flywheel Baer Big Brake Kit
#105010, "RE: Sunroof leak HELP" In response to Reply # 3
my sunroof leaks between the window and rubber seal. I was trying to see that maybe I will need to change the seal but seal is attached to the rubber around the top of my car.
#105011, "RE: Sunroof leak HELP" In response to Reply # 4
The seal is there to keep out most of the elements, but it's not waterproof. If you're getting dripping inside the car the drains are clogged. Even most aftermarket sunroofs have some kind of drain. Sometimes you can open the sunroof and run a coathanger wire down the drain tubes to break loose the clog. Just be careful that you don't push too hard and damage the drain tubes because they're a bitch to run back down through the frame of the car.
Erik P. Official 2GNT thread Hijacker Some say that he's driven over more Covenant than he's shot, and that his grenades aren't where you'd expect them to be... All we know is, He's not The Stig... But he is The Stig's Spartan cousin!
#105015, "RE: Sunroof leak HELP" In response to Reply # 6 Nov-04-10 01:07 PM by bullettdsm
Picture and thousands and all that shit;
I just happen to have taken one off recently. All 4 corners of the window have drains. You will not be able to easily see them if it is installed. Here is a couple of pics of one corner (the screwdriver is stuck in the hose hole);
First from the top;
And this is from the interior side;
The two front tubes go down behind the tire underneath the fender. I'm not sure where the back two tubes go to. These drain tubes can get clogged and then backfill into the interior/headliner.
Captain Caveman
96 RS Turbo 11.414 @ 119.62 MSNS, Crower 2 NA cams, BW366, 10.5 comp, UDP, 60mm TB, W/A intercooler, 3.55 tranny 567.9whp 430tq 97 RS NA 13.188 @ 103.87 MSnS powered 12.5 comp, Crower 3's and 219.4whp with 175tq 98 RS DD 12.5 comp on stock ECU, LTH, Crower 2's, Koni, GC, Hypercoil, DG hats 99 OZ 5sp Stocker 15.856 @ 85.97 99 GS stocker auto 17.7@77mph!